低温蒸发结晶

低温蒸发结晶

低温蒸发结晶整个系统将由真空泵抽成真空,蒸发室的真空度约为95%~97%(表压为-0.095~-0.097mpa),在此条件下的蒸发温度为32℃~35℃。物料无需用泵,利用系统的负压将物料吸进蒸发室,喷成雾状,然后水分被蒸发,陈品通过离心泵循环进入蒸发室,达到要求的浓度后出料。

产品详情

一、低温蒸发器的运行原理
the operating principle of low temperature evaporator

低温蒸发结晶整个系统将由真空泵抽成真空,蒸发室的真空度约为95%~97%(表压为-0.095~-0.097mpa),在此条件下的蒸发温度为32℃~35℃。物料无需用泵,利用系统的负压将物料吸进蒸发室,喷成雾状,然后水分被蒸发,陈品通过离心泵循环进入蒸发室,达到要求的浓度后出料。

浓缩液由于粘度较大,所以采用螺杆泵抽出。设备可在出口处配备一个测定仪,在不接触负压情况下根据介质密度,自动卸料,保证产品的浓度控制。整个操作过程通过程序控制,操作简单,节省人力。

The whole system consists of vacuum pump and vacuum evaporation chamber, the vacuum degree is about 95%~97% (g -0.095~-0.097mpa), evaporation temperature under the condition of 32 DEG ~35 deg. No need to pump material, making use of the system will be sucked into the negative pressure material evaporation chamber, spray into the mist, then the water is evaporated, Chen enters into the evaporation chamber by centrifugal pump, to achieve the required concentration after discharge.

Because of the viscosity of the concentrated liquid, so the screw pump. The equipment can be equipped with a measuring instrument at the outlet, which can automatically discharge the material according to the density of the medium without touching the negative pressure to ensure the concentration control of the product. The whole operation process is controlled by the program, the operation is simple, and the manpower is saved.

二、低温蒸发器的优点
Advantages of low temperature evaporator

国内传统的常规蒸发器一般都是分离式的,占地面积大,浪费空间。该设备无需使用蒸汽,直接接通水、电即可运行,节能环保。自带热泵循环,冷却用水由系统自行补偿产生,节约能源,减少工业废水的处理费用。处理后的冷凝水可循环使用或达到零排放。富集的盐分和重金属等需另行处理。(委托第三方)

The traditional conventional evaporators in China are generally separated, which covers a large area and wastes space。 The equipment does not need to use steam, directly connected to water, electricity can run, energy saving and environmental protection。 With the heat pump cycle, cooling water by the system to generate their own compensation, save energy, reduce the cost of industrial wastewater treatment。 The treated condensate can be recycled or used to achieve zero emissions。 Enriched salt and heavy metals should be treated separately。 (third party)

三、低温蒸发器的特有技术
Special technology of low temperature evaporator

1.全自动控制,处理水质效果好,清洁无异味。
2.无需外加热源,通过利用特种冷凝液运行的热泵获得必要的热能,可比常规利用外加热源的蒸发器节能50%,减少运营成本。也无需外接冷凝系统,节约循环冷却水。
3.在不接触负压的情况下,根据介质密度测定,自动卸料。
4.设备上设有观察窗,可随时观察蒸发情况。
5.设备运行的同时,可对蒸馏液和浓缩液进行取样化验。
6.设备性能稳定,连续运行。

1. fully automatic control, water treatment effect is good, clean no smell.
2. do not need external heat source, through the use of special condenser operation of the heat pump to obtain the necessary heat energy, can be more than the conventional use of external heat source evaporator energy saving 50%, reduce operating costs. No external condensation system is needed to save circulating cooling water.
3. in the absence of contact with the negative pressure, according to the medium density measurement, automatic discharge.
4. the equipment is provided with an observation window, and the evaporation can be observed at any time.
5. when the equipment is running, it can be used for sampling and analysis of distilled liquor and concentrate.
6. stable equipment performance, continuous operation.

四、低温真空蒸发器与多效蒸发器生产能耗成本对比Comparison of energy consumption cost between low temperature vacuum evaporator and multi effect evaporator

上一条: 在线清洗

下一条: 无

询盘

时时彩平台 秒速赛车开户 加拿大28 陕西体彩网 秒速赛车开户 秒速赛车网站 立即博 广东快乐十分 快3平台